1. المقدمة
This manual provides essential instructions for the safe and efficient operation, installation, and maintenance of your Vollrath ServeWell 3-Well Hot Food Table, Model 38003. This unit is designed for commercial food holding applications, ensuring food is kept at optimal serving temperatures. Please read this manual thoroughly before operating the equipment.
Figure 1: Vollrath ServeWell 3-Well Hot Food Table, Model 38003. This image displays the stainless steel construction, three food wells, and the control panel with individual thermostat knobs.
2. تعليمات السلامة
- Always ensure the unit is properly grounded to prevent electrical shock.
- لا تقم بتشغيل الجهاز إذا كان سلك الطاقة أو القابس تالفًا. اتصل بفنيي الصيانة المؤهلين لإجراء الإصلاحات.
- Keep hands and utensils away from hot surfaces and heating elements during operation.
- Use caution when handling hot food pans and draining hot water from the wells.
- تأكد من وجود تهوية كافية حول الوحدة لمنع ارتفاع درجة الحرارة.
- افصل الطاقة قبل تنظيف الوحدة أو صيانتها.
- هذا الجهاز مخصص للاستخدام التجاري فقط.
3. الإعداد والتثبيت
- فك التعبئة: Carefully remove the unit from its packaging. Inspect for any shipping damage. Report any damage to the carrier immediately.
- الموقع: Position the hot food table on a stable, level, non-combustible surface. Ensure there is sufficient clearance around the unit for air circulation and safe operation.
- التوصيل الكهربائي: Connect the unit to a dedicated electrical outlet that matches the voltagه و amperage requirements (1440 Watts total, 480 Watts per well). Ensure the circuit is properly grounded.
- التنظيف الأولي: Before first use, clean all surfaces that will come into contact with food. Refer to the "Maintenance" section for cleaning instructions.
- تعبئة المياه: Fill each well with approximately 1 inch of clean water. Do not overfill.
4. تعليمات التشغيل
The ServeWell Hot Food Table is designed to hold pre-heated food at safe serving temperatures. It is not intended for cooking raw food or reheating cold food.
- تشغيل الطاقة: Ensure the unit is plugged in. Turn the main power switch (if present) to the ON position.
- Fill Wells: Ensure each well contains approximately 1 inch of water.
- سخن: Turn the individual thermostat control knobs for each well to the desired temperature setting. Allow the unit to preheat for at least 20-30 minutes before placing food pans.
- تحميل الطعام: Place pre-heated food in appropriate food pans (up to 4 inches deep, full size or fractional) into the wells.
- التحكم في درجة الحرارة: The automatic thermostat controls will maintain the set temperature. Monitor food temperatures regularly using a food thermometer to ensure compliance with food safety standards.
- تصرف: After use, allow the unit to cool. Use the brass drain valves located under each well to safely drain water.
- إيقاف التشغيل: Turn all thermostat control knobs to the OFF position and disconnect the unit from the power supply when not in use.
5. الصيانة والتنظيف
Regular cleaning and maintenance will extend the life of your hot food table and ensure sanitary operation.
- التنظيف اليومي:
- Disconnect power and allow the unit to cool completely.
- Drain water from the wells using the brass drain valves.
- Clean the interior and exterior surfaces with a mild detergent and warm water. Use a soft cloth or sponge.
- Rinse thoroughly and dry completely to prevent water spots and corrosion.
- لا تستخدم المنظفات الكاشطة أو الصوف الصلب أو المواد الكيميائية القاسية، لأنها قد تتلف طبقة الفولاذ المقاوم للصدأ.
- إزالة الترسبات: Periodically descale the wells to remove mineral buildup, especially in areas with hard water. Follow manufacturer's instructions for descaling agents.
- تقتيش: Regularly inspect the power cord, plug, and control knobs for any signs of wear or damage.
6. استكشاف الأخطاء وإصلاحها
| مشكلة | السبب المحتمل | حل |
|---|---|---|
| الوحدة لا تسخن | No power; thermostat set too low; faulty heating element. | Check power connection and circuit breaker; increase thermostat setting; contact service technician. |
| Food not holding temperature | Insufficient water in wells; thermostat set too low; food not pre-heated; pans not covered. | Ensure wells have adequate water; increase thermostat setting; always use pre-heated food; cover food pans. |
| Water leaks from well | Drain valve not fully closed; damaged well. | Ensure drain valve is securely closed; contact service technician for well inspection. |
7. المواصفات
- نموذج: 38003
- Wells: 3
- قوة: 1440 Watts total (480 Watts per well)
- الأبعاد (المنتج): 48.25 بوصة (طول) × 35 بوصة (عرض) × 17 بوصة (ارتفاع)
- وزن السلعة: 140 رطل
- لوح التقطيع: 8 inches wide (integrated)
- عناصر التحكم: Automatic thermostat controls for each well
- Well Material: Thermostat wells designed to resist pitting or rusting
- الصرف الصحي: Brass drain valves for each well
- Recommended Pan Depth: Up to 4 inches (full size or fractional pans)
8. معلومات الضمان
The manufacturer's warranty for this product does not apply to units purchased for personal, family, or household use. This warranty is specifically for commercial applications. For detailed warranty terms and conditions, please refer to the documentation provided with your purchase or contact Vollrath customer support.
9. دعم العملاء
For technical assistance, parts, or service inquiries regarding your Vollrath ServeWell Hot Food Table, please contact Vollrath customer support. Ensure you have your model number (38003) and serial number available when contacting support.
You can find contact information on the official Vollrath webالموقع أو من خلال الوكيل المعتمد لديك.
